You must write the customers concern fault the front the job card

	AURLTX002 Diagnose and repair light vehicle automatic transmissions

Student Name

Unit End Date

Assessment Due Date

The assessment process and tasks were fully explained.

Yes

I am aware of which evidence will be collected and how.

Yes

Cheating & Plagiarism Declaration

Student Declaration: In accordance with TheRTO Plagiarism Policy, I hereby acknowledge by signing this declaration that I have not cheated or plagiarised any work regarding the assessment tasks undertaken in this unit of competency except where the work has been correctly acknowledged.

NOTE: Student must sign this prior to submitting their assessments to the assessor

Date

Assessment Results	(Please circle the assessment result for this task)

			Assessor Name:
Student Signature: Ankush kumar

Overview of Assessment	Instructions to include, but not limited to: 1. Assessors will observe the student completing the service tasks. 5. If there is a clear breach of safety, assessors MUST intervene immediately and advise the student of the breach. 6. Students MUST successfully diagnose and repair light vehicle automatic transmissions before competency can be achieved for the practical component.
	The student MUST diagnose and repair light vehicle automatic transmissions for specific applications that safely follows workplace procedures to meet required outcomes. o Transmission oil pump o Front pump seal o Brake band servo o One-way clutch
Oral questioning	During the practical demonstration your assessor will ask you questions that will address the knowledge aspects of the unit of competency. You will respond orally, and your assessor will record your response.

Time allowed

You should have practiced these practical tasks and feel comfortable completing the tasks before attempting the practical assessment.

Decision making rules

Expected answers to oral questions are indicative of the correct answer.

Your assessor will be looking for the following in this assessment task: -

components:

o Torque converter

o Clutch pack

o Brake band

o Internal bearings or thrust washers

 Remove, refit or replace one of the above light vehicle automatic transmission.



 Access and understand the correct workshop manual for the light vehicle automatic transmission being dia gnosed.

				Created Date:	12th Aug 2019
			2.0
© Trinity Institute (Australia) \| RTO Code: 41310 \| CRICOS Code: 3556F				Page Sequence:

Resources required

The following equipment will be made available to students:

   

Results/Re-assessment



 If the evidence is graded as NS – Not Satisfactory you will be required to re-submit the evidence. In this case, you will be provided with clear and constructive feedback based on the assessment decision so that they can improve your skills / knowledge prior to reassessment.

Reasonable Adjustment

Upon completion of this task, you should be able to demonstrate how to diagnose and repair light vehicle automatic

transmissions.

o Front pump seal

o Valve body

o One-way clutch

o Planetary gear set

Your Trainer/Assessor has setup the vehicle with a light vehicle automatic transmissions fault. Your Trainer/Assessor

will observe you against the performance observation criteria for diagnose and repair light vehicle automatic

WARNING!
The Assessment will be STOPPED IMMEDIATELY if you are attempting to carry out any step in an unsafe or dangerous way.

	Student Practical Demonstration of Tasks – AURLTX002			Created Date:
			2.0	Last Modified Date:
© Trinity Institute (Australia) \| RTO Code: 41310 \| CRICOS Code: 3556F

7. You MUST repair the light vehicle automatic transmissions as specified in the vehicles workshop manual. 8. You MUSTcomplete post repair testing to confirm repair

Customer:	TRINITY	Contact Details:		(H) 02848874			2158
		City:	KINGS PARK	State:		Post code:	2158

Vehicle Details (Must fill in the vehicle details) If simulated environment used, please tick 

VIN No:	JN1CBAN16A0079981	Engine Type:		210512	AUTOMATIC
		Engine Type:		Trans Type:	AUTOMATIC

Customer Concern

THERE WAS SOME WEIRD VOICE AND SHIFTING WAS HARD THAN NORMAL

	Record of Conversation with Customer:
PRESSURE SOLENOID FAULTY	Date: 20/03/2021

Time: 2:00 – 5:30

SINCE HOW LONG YOU ARE DRIVING
THE CAR AFTER PROBLEM

	Parts Used

DO GET A TRANSMISSION SERVICE FOR 5000 KMS


Document No:	Trinity Institute (Australia)– AURLTX002		2.0
					Page 9 of 14

	Tyre Report		Time
		R/H/F	ON
Auto Oil	mm	mm	OFF
		R/H/R
	mm	mm	OFF
Coolant	Brake Report
		R/H/F	OFF
	mm	mm	ON
	L/H/R	R/H/R	ON
	L/H/R	R/H/R	OFF
	mm	mm
	mm	mm	OFF

					12th Aug 2019
Document No:			2.0
				Page Sequence:	Page 10 of 14

transmissions.

You MUST diagnose and repair light vehicle automatic transmissions in which the fault MUST involve one [1] of the

o Valve body

o Shift or pressure solenoid

o Planetary gear set

o Continuously variable transmission (CVT) belt or pulley

will observe you against the performance observation criteria for diagnose and repair light vehicle automatic

transmissions.

WARNING!
The Assessment will be STOPPED IMMEDIATELY if you are attempting to carry out any step in an unsafe or dangerous way.

Document Name:
	Trinity Institute (Australia)– AURLTX002	Version No:	2.0

7. You MUST repair the light vehicle automatic transmissions as specified in the vehicles workshop manual.
Job Card 2
Customer Details
Customer:
Address:		62 TATTERSAL ROAD				State:			Post code:
Vehicle Details (Must fill in the vehicle details) If simulated environment used, please tick 
Make:	HYUNDAI			Colour:			License No:
VIN No:	MALBB51CMFM663769				Odometer Reading:			141000
Engine No:			Engine Type:				Trans Type:

THERE WAS A NOISE FROM GEARBOX

	AURLTX002 Diagnose and repair light vehicle automatic transmissions

					12th Aug 2019
Document No:			2.0
				Page Sequence:	Page 13 of 14





MONITOR TRANSMISSION OPERATION




Fluids	Tyre Report		Tech #	Job #	Time
		R/H/F			ON
Auto Oil	mm	mm			OFF
	L/H/R	R/H/R
	mm	mm			OFF
	Brake Report				ON
P/S Oil		R/H/F			OFF
	mm	mm
	L/H/R	R/H/R			OFF
	mm	mm			ON
					OFF

Document Name:	Student Practical Demonstration of Tasks – AURLTX002
		Version No:	2.0	Last Modified Date: